filename: tfs 110w.doc version 1.3 07.10.2005 vi telefilter filter specification tfs 110w 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. measurement condition ambient temperature: 25 c input power level: 0 dbm terminating impedance: * input: 297 ? || -23,3 pf output: 315 ? || -24,6 pf characteristics remark: the reference level for the relative attenuation a rel of the tfs 110w is the minimum of the pass band a ttenuation. this value is defined as the insertion loss a e . the nominal frequency f n is fixed at 110,592 mhz without any toleranc e. the values of relative attenuation a rel are guaranteed for the whole operating temperature range. the frequency shift of the filter in the operating temperature range is included in the production tolerance scheme. d a t a typ. value tolerance / limit insertion loss a e 3,5 db max. 4,5 db (reference level) nominal frequency f n - 110,592 mhz centre frequency f c 110,592 mhz - passband pb f n 280 khz pass band ripple - max. 3 db relative attenuation a rel f n ? f n 0,280 mhz 1 db max. 3 db f n 1,150 mhz ? f n 1,728 mhz 18 db min. 10 db f n 1,728 mhz ? f n 3,456 mhz 35 db min. 30 db f n + 3,456 mhz ? f n + 5,184 mhz 45 db min. 40 db f n - 3,456 mhz ? f n - 5,184 mhz 49 db min. 45 db f n - 5,184 mhz 53 db min. 50 db f n - 5,184 mhz ? f n - 15,000 mhz 50 db min. 40 db group delay ripple within pb p-p 100 ns max. 700 ns input power level max. 0 dbm permissible dc voltage max. 3 v operating temperature range otr - - 20 c ... + 70c storage temperature range - - 40 c ... + 85c temperature coefficient of frequency tc f ** -19 ppm/k *) the terminating impedances depend on parasites and q-values of matching elements and the board used, and are to be understoo d as reference values only. should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ? f c (hz) = tc f (ppm/k) x (t - t a ) x f cat (mhz) generated: checked / approved:
filename: tfs 110w.doc version 1.3 07.10.2005 vi telefilter filter specification tfs 110w 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. filter characteristic construction and pin connection (all dimensions in mm) date code 50 ohm test circuit l1 l2 saw l3 l4 10 5 1, 2, 3, 6, 7, 8 4 9 s 110w t41 1 ground 2 ground 3 ground 4 output rf return 5 output 6 ground 7 ground 8 ground 9 input rf return 10 input date code: year + week t 2005 u 2006 v 2007 ... 100.6 102.6 104.6 106.6 108.6 110.6 112.6 114.6 116.6 118.6 120.6 -60 -54 -48 -42 -36 -30 -24 -18 -12 -6 0 frequency in mhz magnitude in db 109.85 110 110.15 110.3 110.45 110.6 110.75 110.9 111.05 111.2 111.35 -10 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 frequency in mhz magnitude in db 109.85 110 110.15 110.3 110.45 110.6 110.75 110.9 111.05 111.2 111.35 0.18 0.72 1.26 1.8 2.34 2.88 3.42 3.96 4.5 5.04 5.58 frequency in mhz delay in s
filename: tfs 110w.doc version 1.3 07.10.2005 vi telefilter filter specification tfs 110w 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. stability characteristics after the following tests the filter shall meet the whole specification: 1. shock: 500g, 1 ms, half sine wave, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely, 1 octave per min, 10 cycles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cycles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; packing tape & reel: iec 286 ? 3, with exeption of value for n and minimum bending radius; tape type ii, embossed carrier tape with top cover tape on the upper side; max. pieces of filters peer reel: 3000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao pull off direction pin marker typ date code ko t a c n w 1 w 2 the minimum bending radius is 45 mm. tape (all dimensions in mm) w : 16,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 7,50 0,1 g(min) : 0,60 p2 : 2,00 0,1 p1 : 8,00 0,1 d1(min) : 1,50 a o : 5,50 0,1 bo : 7,50 0,1 ct : 13,5 0,1 reel (all dimensions in mm) a : 330 w1 : 16,4 +2/-0 w2(max) : 22,4 n(min) : 50 c : 13,0 +0,5/-0,2
filename: tfs 110w.doc version 1.3 07.10.2005 vi telefilter filter specification tfs 110w 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. air reflow temperature conditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c between 300 and 600 seconds > 150c between 240 and 500 seconds > 217c between 30 and 150 seconds peak temperature max. 260c time within 5c of actual peak temperature between 10 and 30 seconds cool-down rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds temperature / c time / s max. 260c 217c 10 ... 30 s 30 ... 150 s max. 300 s chip-mount air reflow profile
filename: tfs 110w.doc version 1.3 07.10.2005 vi telefilter filter specification tfs 110w 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. history version reason of changes name date 1.0 - generation of development specification strehl 10.06.2005 1.1 - change pass band and relative attenuation strehl 13.07.2005 1.2 - terminating impedance (preliminary value), typica l values and filter characteristic added pfeiffer 02.09.2005 - matching configuration changed 1.3 - terminating impedance fixed pfeiffer 07.10.2005 - typical values and filt er characteristic changed
|
